Staying Safe at the Pump
Accidents can happen, even at the gas pumps. Here are a few tips when pumping fuel into your vehicle or a portable container. Never allow children under driving age to operate the pump. Avoid breathing vapors. Keep gasoline away from your eyes and skin. Never siphon gasoline by mouth, gasoline can be harmful or fatal if swallowed, contact a doctor or emergency facility in an emergency. Also, do not over-fill or top-off your vehicle tank.
When Filling Up Your Vehicle.
- Turn off your vehicle engine. Put your vehicle in park and/or set the emergency brake. Disable or turn off any auxiliary sources of ignition such as a camper or trailer heater, cooking units, or pilot lights.
- Do not smoke, light matches or lighters while refueling at the pump or when using gasoline anywhere else.
- Use only the refueling latch provided on the gasoline dispenser nozzle. Never jam the refueling latch on the nozzle open.
- Do not re-enter your vehicle during refueling. If you cannot avoid re-entering your vehicle, discharge any static build-up BEFORE reaching for the nozzle by touching something metal with a bare hand -- such as the vehicle door -- away from the nozzle.)
- In the unlikely event a static-caused fire occurs when refueling, leave the nozzle in the fill pipe and back away from the vehicle. Notify the station attendant immediately.
- When dispensing gasoline into a container, use only an approved portable container and place it on the ground to avoid a possible static electricity ignition of fuel vapors. Containers should never be filled while inside a vehicle or its trunk, the bed of a pickup truck or the floor of a trailer.
- When filling a portable container, manually control the nozzle valve throughout the filling process. Fill a portable container slowly to decrease the chance of static electricity buildup and minimize spilling or splattering. Keep the nozzle in contact with the rim of the container opening while refueling.
- Fill container no more than 95 percent full to allow for expansion.
- Place cap tightly on the container after filling - do not use containers that do not seal properly.
- Only store gasoline in approved containers as required by federal or state authorities. Never store gasoline in glass or any other unapproved container.
- If gasoline spills on the container, make sure that it has evaporated before you place the container in your Vehicle Report spills to the attendant.
- When transporting gasoline in a portable container make sure it is secured against tipping and sliding, and never leave it in direct sunlight or in the trunk of a car.